1、Designation:D123022Standard Test Method forFlammability of Apparel Textiles1This standard is issued under the fixed designation D1230;the number immediately following the designation indicates the year oforiginal adoption or,in the case of revision,the year of last revision.A number in parentheses i
2、ndicates the year of last reapproval.Asuperscript epsilon()indicates an editorial change since the last revision or reapproval.1.Scope1.1 This test method covers the evaluation of the flamma-bility of textile fabrics as they reach the consumer for apparelitems other than childrens sleepwear or prote
3、ctive clothing.1.2 This test method is used to measure and describe theresponse of materials,products,or assemblies to heat and flameunder controlled conditions,but does not by itself incorporateall factors required for fire hazard or fire risk assessment of thematerials,products,or assemblies under
4、 actual fire conditions.1.3 Fire testing is inherently hazardous.Adequate safe-guards for personnel and property shall be employed inconducting these tests.NOTE1This test method is not identical to 16 CFR Part 1610,Flammability of Clothing Textiles.Consumer Product Safety Commissionregulations requi
5、re that clothing fabrics introduced into commerce meetthe requirements of 16 CFR Part 1610.1.4 The values stated in SI units are to be regarded as thestandard;inch-pound units are provided for information only.1.5 This standard does not purport to address all of thesafety concerns,if any,associated
6、with its use.It is theresponsibility of the user of this standard to establish appro-priate safety,health,and environmental practices and deter-mine the applicability of regulatory limitations prior to use.1.6 This international standard was developed in accor-dance with internationally recognized p
7、rinciples on standard-ization established in the Decision on Principles for theDevelopment of International Standards,Guides and Recom-mendations issued by the World Trade Organization TechnicalBarriers to Trade(TBT)Committee.2.Referenced Documents2.1 ASTM Standards:2D123 Terminology Relating to Tex
8、tilesD3136 Terminology Relating to Care Labeling for Apparel,Textile,Home Furnishing,and Leather ProductsD4391 Terminology Relating to The Burning Behavior ofTextilesE176 Terminology of Fire Standards2.2 AATCC Test Method:3124-2011 Smoothness Appearance of Fabrics after Re-peated Home Laundering2.3
9、CPSC Guidance Document:416 CFR Part 1610 Standard for the Flammability of ClothingTextiles October 20082.4 ISO Standards5ISO 4880 Burning behaviour of textiles and textile productsISO 13943 Fire safety3.Terminology3.1 The following terms are relevant to this standard:baseburn,burn time,combustible t
10、extile,dry cleaning,flameapplication time,flame spread,flame-spread time,flameretardant,flame-retardant-treated,flammability,ignition,interlining,laundering,plain surface textile fabric,raised fibersurface,refurbish,surface flash.3.2 For terms related to burning behavior of textiles,seeTerminology D
11、4391.3.3 For terms related to fabric treatments and finishings,seeTerminology D3136.3.4 For terms related to fabric treatments and finishings,seeTerminology in the referenced AATCC test method.3.5 For terminology related to fire issues other than burningbehavior of textiles,see Terminology E176 and
12、ISO 13943.Incase of conflict,the terminology in E176 will prevail.3.6 For other terms related to textiles,see TerminologyD123 and the American Association of Textile Chemists andColorists test method.1This test method is under the jurisdiction ofASTM Committee D13 on Textilesand is the direct respon
13、sibility of Subcommittee D13.52 on Flammability.Current edition approved Feb.1,2022.Published May 2022.Originallyapproved in 1952.Last previous edition approved in 2017 as D123017.DOI:10.1520/D1230-22.2For referenced ASTM standards,visit the ASTM website,www.astm.org,orcontact ASTM Customer Service
14、at serviceastm.org.For Annual Book of ASTMStandards volume information,refer to the standards Document Summary page onthe ASTM website.3AATCC Technical Manual of the American Association of Textile Chemistsand Colorists,P.O.Box 12215,Research Triangle Park,NC 27709.4Available from the U.S.Consumer P
15、roduct Safety Commission,www.cpsc.gov.5Available from International Organization for Standardization(ISO),1,ch.dela Voie-Creuse,Case postale 56,CH-1211,Geneva 20,Switzerland,http:/www.iso.ch.Copyright ASTM International,100 Barr Harbor Drive,PO Box C700,West Conshohocken,PA 19428-2959.United StatesT
16、his international standard was developed in accordance with internationally recognized principles on standardization established in the Decision on Principles for theDevelopment of International Standards,Guides and Recommendations issued by the World Trade Organization Technical Barriers to Trade(TBT)Committee.14.Summary of Test Method4.1 The test method provides methods of testing the flam-mability of textiles from or intended to be used for apparel,explains three classes of flammability,sets
